Surface-acoustic-wave (SAW) flow sensor
- 1 March 1991
- journal article
- Published by Institute of Electrical and Electronics Engineers (IEEE) in IEEE Transactions on Ultrasonics, Ferroelectrics, and Frequency Control
- Vol. 38 (2) , 148-154
- https://doi.org/10.1109/58.68472
Abstract
The use of a surface-acoustic-wave (SAW) device to measure the rate of gas flow is described. A SAW oscillator heated to a suitable temperature above ambient is placed in the path of a flowing gas. Convective cooling caused by the gas flow results in a change in the oscillator frequency. A 73-MHz oscillator fabricated on 128 degrees rotated Y-cut lithium niobate substrate and heated to 55 degrees C above ambient shows a frequency variation greater than 142 kHz for flow-rate variation from 0 to 1000 cm/sup 3//min. The output of the sensor can be calibrated to provide a measurement of volume flow rate, pressure differential across channel ports, or mass flow rate. High sensitivity, wide dynamic range, and direct digital output are among the attractive features of this sensor. Theoretical expressions for the sensitivity and response time of the sensor are derived. It is shown that by using ultrasonic Lamb waves, propagating in thin membranes, a flow sensor with faster response than a SAW sensor can be realized.<>Keywords
This publication has 16 references indexed in Scilit:
- Mass flow sensing using surface acoustic wavesPublished by Institute of Electrical and Electronics Engineers (IEEE) ,2003
- Use of a surface-acoustic-wave (SAW) device to measure gas flowIEEE Transactions on Instrumentation and Measurement, 1989
- A highly sensitive silicon chip microtransducer for air flow and differential pressure sensing applicationsSensors and Actuators, 1987
- Surface Acoustic Wave Flow SensorPublished by Institute of Electrical and Electronics Engineers (IEEE) ,1985
- Monolithic integrated direction-sensitive flow sensorIEEE Transactions on Electron Devices, 1982
- Pyroelectric anemometers: preparation and flow velocity measurementsSensors and Actuators, 1981
- Observations on the Short Term Stability of a SAW Delay Line OscillatorPublished by Institute of Electrical and Electronics Engineers (IEEE) ,1980
- New Method for Determining Temperature Coefficients of Bare PiezoelectricsPublished by Institute of Electrical and Electronics Engineers (IEEE) ,1979
- Surface acoustic wave devices and applicationsUltrasonics, 1974
- XII. On the convection of heat from small cylinders in a stream of fluid: Determination of the convection constants of small platinum wires with applications to hot-wire anemometryPhilosophical Transactions of the Royal Society A, 1914