IN VITRO VISCOSITY MEASUREMENTS OF BARLEY EXTRACTS AS PREDICTORS OF GROWTH RESPONSES IN CHICKS FED BARLEY-BASED DIETS SUPPLEMENTED WITH A FUNGAL ENZYME PREPARATION

Publisher Website
Google Scholar
Abstract
The effects of in vitro extracting conditions on the viscosity of different barley cultivars were determined (exps. 1–3). Then, the relationship between three in vitro viscosity assays (method I, raw barley-HCl-KCl buffer; method II, autoclaved barley-H2O; and method III, raw barley-H2O) was compared with the performance of chicks fed barley-based diets supplemented with fungal enzyme (exp. 4). A significant three-way interaction (P < 0.0001) among fineness of grind, extraction method and barley cultivar showed that viscosity values for different barleys were not uniformly affected by the other two factors. Part of this differential response was eliminated by the use of finely ground barley (< 0.5-mm-mesh screen). When the three extracting methods were compared, method I gave higher readings than method II for high-viscosity barleys, and the reverse was true for low-viscosity barleys. The ranking of the barleys remained the same. Method III gave the lowest viscosity values, perhaps due to active endogenous β-glucanases in water extracts of the raw barley. When different barley cultivars were extracted by method I and subjected to different shear rates the viscosity differences were much more pronounced at the lower shear rates, particularly for high-viscosity barleys. Finally, the same seven barleys were compared in a feeding trial with chickens. The improvement in weight gain due to supplementation with a crude enzyme preparation from Trichoderma viride (Cellulase Tv) ranged from 2 to 41 % (P < 0.05). Similar improvements were obtained for feed consumption, feed-to-gain ratio and dry matter retention (P < 0.05). The highest simple correlation coefficients were between the viscosity of barleys that had been extracted by method I, measured at low shear rates, and relative weight gain (r = 0.97, week 1 plus week 2). The correlation coefficients using low shear rate data were slightly higher than those with high shear rate data. These results indicate that most pronounced differences among barleys were obtained with finely ground samples (<0.5 mm), extracted for one hour at 38 °C, using a low pH 1.5 buffer (method I) and assayed at low shear rates. Under these conditions the viscosity data reflected the antinutritive properties of barley, which in turn were reduced or abolished by adding a crude enzyme preparation to the diet. Key words: Viscosity, barley extracts, chicks, fungal enzyme

This publication has 0 references indexed in Scilit: